China Ozone Car Disinfector

Technical Parameters

ModelWGL-TXSize(L*W*H)210*150*160mmPacking Size (L*W*H)260*160*210mmOzone output(g/h)5Weight(KG)2.2ozone concentration(mg/L)15-20Power(W)60WInput VoltageDC12VPlugCigarette lighter or adapterCooling WayAir coolingWorking ConditionsEnvironment Temperature≤45ºC,RH≤80%Timer
0-90min

Product Core Construction (Configuration Technology Advantages)
(1) ozone tube: the dielectric material is made of high purity dehydroxyquartz tube, the dehydroxylation is less than 10 ppm,SiO2 the content is over 98%, the temperature resistance is 1600 degrees, and the voltage resistance is 30 KV, far higher than the peak high voltage 7 produced by the matching high frequency high voltage power supply. it will not be destroyed by high voltage breakdown. Internal and external electrodes :316 L stainless steel material, corrosion resistance is better than 316 L stainless steel, in high voltage and high frequency continuous discharge situation, use 20,000 hours will not be oxidized blackening rust deformation; service life of more than 5 years
(2)High frequency high voltage power supply: rectifier converter circuit,ignition coil by the iron core,iron oxide composite layer of polyester imide/polyamide imide enamelled wire,high temperature vacuum potting glue,epoxy with open circuit protection,over current protection,over-voltage protection,short circuit protection,high frequency 3-20 KHZ,sine wave output waveform,heavily converts electrical energy,power factor can reach 0.97.
Environmental conditions

Operating Temperature0ºC to +40ºCAltitudeIf >1000 meters above sea level, the cooling effect become bad and the air outlet of air compressor will reduce HumidityMaximum 85% relative humidityAtmosphereNon-flammable, corrosive and conductive dust Atmospheric Pressure101.3KPa standard atmospheric pressure is requiredWorking Area ConditionsKeep the room for ozone generator system dry and ventilated

Operating methods
air treatment (sterilization, deodorization, formaldehyde)
1.1: Start the car, connect one end of the power cord to the Car cigarette lighter and the other end to the power input
1.2: Rotate the timing switch clockwise to the required disinfection time scale (or rotate the timing switch counterclockwise to the normal open position), the equipment starts to work and the ozone output port has ozone output. To zero, the equipment automatically stops.
1.3: In order to achieve the best ozone disinfection effect, please close the windows and so on, when disinfection do not have personnel in the car.
1.4: During use, it is recommended to turn on the air conditioning internal circulation
Ozone Knowledge
Ozone is an oxygen molecule made up of three oxygen atoms. The molecular formula is O3, one of which is connected with the other two oxygen atoms in the form of a single bond. Ozone is known as "green chemicals", is a strong oxidizing agent. It has four main functions of sterilization, decolorization, oxidation, deodorization and no residue, no pollution, is one of the environmental friendly green industrial raw materials. Ozone is one of the most powerful solutions for municipal, industrial and commercial water treatment challenges.
The sterilization ability
Ozone has strong oxidation, has been recognized as a kind of broad-spectrum efficient fungicide, 600-3000 times faster than the chlorine in the water, and even can kill bacteria, within a few seconds including common coli, streptococcus, pseudomonas aeruginosa, staphylococcus mould etc. If keeping the environment 0.3 PPM concentrations of ozone in 5 minutes, the killing rate can reach more than 99%.Its sterilization and disinfection effects occur almost instantaneously. When ozone concentration in water reaches 0.3-2ppm, bacteria can be killed within 0.5-1min.The dose of ozone water is required to achieve the same sterilization effect (e.g., 99% of escherichia coli kill rate) is only 0.0048% of that of chlorine.
Resolving time
In air at room temperature and pressure is about 10-30 minutes.Finally,ozone is reduced to oxygen.
Ozone is a safe, non-residual oxidant and disinfectant,will not cause secondary pollution.Ozone can be rapidly reduced to oxygen by the reaction itself,so no need to worry about chemical residues and no threat to the living environment.
Why Choose Us?
1. EXPERIENCE :11 years focus on ozone generator R&D and manufacture,service of more than 1000 customers.
2. 30000 square meter factory area
3. Core patent technology and authorized certifications
4. Strict quality control to ensure safe and reliable products
5.Service: 24 hours online service,life-long maintenance
6.Professional overseas sales team, supply prompt response
FAQ

We are manufacturer and trader. Generally it's 5 days if the goods are available. It would be 20-30 days based on ozone application and capacity requirements.We could supply ODM and OEM, design layout based on actual working condition. Yes, we could offer the sample. After receiving 100% payment, we will deliver the sample to you as soon as possible. 30% T/T in advance, balance before shippment. The company strictly implements the ISO9001 quality management system, has passed ISO14001, ISO18001 management system certification and SGS. In addition, we have more than 20 patents technology to ensure stable and reliable product quality.Yes, we offer 12 months warranty from the date of the customer's /confirm/iation.Beyond the warranty, we will also supply life-long maintenance but we will charge maintenance fee.

Contact us today for your needs!